Yamaha 4 Stroke 2002-2009 Clymers Manual: Watercraft Superstore
Free Shipping! On Orders Over $75.00 (some restrictions apply)
Product Search

    Secure Checkout

    $39.95

    Yamaha 4 Stroke 2002-2009 Clymers Manual

    Yamaha 4 Stroke 2002-2009 Clymers Manual
    Processing...
    $39.95

    Brand: Clymer
    SKU #: 713SB402
    Shipping Weight: 3.00 pounds
    Quantity in Basket: None



    *** This Manual Does not cover 1800 cc models ***
    *** This Manual Does not cover 2-stroke models ***
    Unlike a factory manual, Clymer manuals are written for the DIY enthusiast. The most important tool in your toolbox may be your Clymer manual, get one today.

    Manual is 288 pages.

    CHAPTER ONE / GENERAL INFORMATION

    CHAPTER TWO / TROUBLESHOOTING
    Engine operating requirements / Starting the engine / Fuel delivery / Ignition system / Electronic fuel injection EFI / Charging system / Warning system / Cooling system / Engine / Compression test

    CHAPTER THREE / LUBRICATION , MAINTENANCE AND TUNE-UP
    Inspection before each use / Fuel leak check / Water separator check / Battery inspection / Steering system check / Throttle control operation / Shift control operation check / Quick shift trim selector QSTS operation check / Drain plug check / Engine oil level / Lanyard switch operation / Water leak inspection / Inspection after each use / Cooling system flush / Cleaning / Periodic maintenance schedule / Engine oil change / Engine oil filter change / Air filter cleaning inspection / Spark plug plugs / Jet pump lubrication / bilge pump screen cleaning / Siphon pump screen cleaning / Water inlet filter cleaning inspection / Valve clearance adjustment and impeller clearance adjustment

    CHAPTER FOUR / ENGINE
    Removal installation / Oil tank / Oil pump / Reduction gear / Camshaft cover cam shaft / Cylinder head / Cylinder block / Oil pressure switch / Engine coolant temperature ECT sensor / Oil pan / Crankcase cover crank case / Piston / Connecting rod / Crankshaft crank shaft cylinder block inspection / Engine bearing selection / Anode / Engine break in

    CHAPTER FIVE / DRIVE SYSTEM AND JET PUMP
    Ride plate / Intake grate / Jet pump assembly / Impeller housing / Impeller / Stator / Stator bearing housing / Intermediate bearing housing / Steering nozzle / Trim nozzle and reverse bucket

    CHAPTER SIX / FUEL SYSTEM
    Air filter / Air filter housing / Throttle body / Fuel rail / Injector injectors / Fuel pump / Fuel pump module / Throttle position sensor TPS / Throttle cable / Idle speed and synchronization

    CHAPTER SEVEN / EXHAUST AND COOLING SYSTEM
    Exhaust pipe / Exhaust outlet / Water tank / Exhaust hose / Water lock / Exhaust tube / Exhaust overheat switch / Exhaust manifold / Cooling system / Thermostat / Thermostat housing / Water pressure relief valve and housing and water inlet filter

    CHAPTER EIGHT / ELECTRICAL SYSTEM
    Battery / Battery cables / Starter / Flywheel fly wheel / Battery charge coil / Pulser coil coils / Ignition coil coils / Engine control unit ECU brain / Main relay / Fuel pump relay / Starter relay / Electronic throttle control relay / Voltage regulator rectifier / Tilt detection switch and color wiring diagrams

    CHAPTER NINE / BILGE SYSTEM
    Operation / Bilge pump / Jet siphon pump and indicator siphon break fitting

    CHAPTER TEN / STEERING, HELM AND CONTROLS
    Handlebar handle bar bars cover / Throttle cable / Throttle control / Quick Shift Trim Selector DSTS / Start - stop and lanyard switch / Steering cable / Steering helm / Steering switch / Steering sensor / Shift cable / Shift lever / Air temperature sensor / Compass assembly

    COLOR WIRING DIAGRAM

    2003 FX 140
    2003 FX Cruiser
    2004 FX 140
    2004 FX Cruiser
    2004 FX Cruiser HO
    2004 FX HO
    2005 FX 140
    2005 FX Cruiser
    2005 FX Cruiser HO
    2005 FX HO
    2005 VX Deluxe
    2005 VX Sport
    2006 FX 140
    2006 FX Cruiser
    2006 FX Cruiser HO
    2006 FX HO
    2006 VX Deluxe
    2006 VX Sport
    2007 FX 140
    2007 FX Cruiser
    2007 FX Cruiser HO
    2007 FX HO
    2007 VX Cruiser
    2007 VX Deluxe
    2007 VX Sport
    2008 FX 140
    2008 FX Cruiser
    2008 FX Cruiser HO
    2008 FX HO
    2008 VX Cruiser
    2008 VX Deluxe
    2008 VX Sport
    2009 VX
    2009 VX Cruiser
    2009 VX Deluxe
    2009 VX Sport
    2003 SR 230
    2004 AR 230
    2004 SR 230
    2005 AR 230
    2005 AR 230 HO
    2005 SR 230
    2005 SX 230
    2005 SX 230 HO
    2006 AR 230
    2006 SR 210
    2006 SX 210
    2006 SX 230
    2007 AR 210
    2007 AR 230 HO
    2007 SR 210
    2007 SX 210
    2007 SX 230 HO
    2008 212SS
    2008 212X
    2008 232 Limited
    2009 232 Limited